1. From the loading mixer truck, check the working conditions of the lubrication points of each rotating part every day and replenish the lubricating oil in time.
2.自上料攪拌車，每天檢查攪拌機潤滑油杯內潤滑油量，及時補給潤滑油。
2. From the loading mixer, check the amount of lubricating oil in the lubricating oil cup of the mixer every day and replenish the lubricating oil in time.
3.每周檢查一次氣路系統上的油霧器的油面高度，使用粘度為2.5~7°E的潤滑油。
3. Check the oil level of the oil atomizer on the air circuit system once a week and use lubricating oil with viscosity of 2.5 ~ 7 ° E.
4.每天在開機前和關機后打開一次排水閥，將空氣壓縮機和儲氣罐內凝聚的水排出。
4. Open the drain valve once a day before startup and after shutdown to discharge the condensed water in the air compressor and air storage tank.
5.緊固件比如螺栓和螺母，要每周檢查是否松動，發現有松動時，必須及時擰緊，尤其是一些受變幅載荷的零部件。
5. Fasteners such as bolts and nuts should be checked weekly for looseness. If looseness is found, they must be tightened in time, especially some parts under variable amplitude load.
6.每天經常檢查供水、供氣及外加劑系統的各設備是否正常。
6. Regularly check whether the equipment of water supply, gas supply and admixture system is normal every day.
7.每天檢查電氣控制系統及各儀表是否正常。
7. Check whether the electrical control system and instruments are normal every day.
8.每天檢查攪拌機的攪拌軸和整體是否干凈清潔，如果攪拌軸上凝結的混凝土過多，必須人工進入清理。
8. Check whether the mixing shaft and the whole of the mixer are clean every day. If there is too much concrete on the mixing shaft, it must be cleaned manually.
9.每半年清理或更換粉料罐除塵器中的過濾網。清理粉料罐除塵器中的過濾網時不能水洗，只能用氣吹或軟毛刷清理。自上料攪拌車，若停機時間超過一周以上的，必須放空各計量斗內的物料，如水泥、水、外加劑及各種骨料，并清洗攪拌主機，出料斗等處，以免物料板結。
9. Clean or replace the filter screen in the dust collector of the powder tank every six months. When cleaning the filter screen in the dust remover of the powder tank, it cannot be washed with water, but can only be cleaned with air blowing or soft bristle brush. If the shutdown time of the self loading mixer exceeds one week, the materials in each metering bucket, such as cement, water, admixture and various aggregates, must be emptied, and the mixing host and discharge hopper must be cleaned to avoid material hardening.
上就是今天全自動混凝土攪拌車為您提供的資訊分享，更多的精彩內容請關注我們的網站：http://www.jqeq.cn，會(huì )有更多的內容為您呈現。
The above is the information sharing provided by today's automatic concrete mixer. For more wonderful contents, please pay attention to our website: http://www.jqeq.cn , there will be more content for you.
