根據混凝土攪拌車使用狀況，結合參考設備累計臺時，安排對混凝土攪拌車進行檢修，檢測、保養、維修、防腐工作。使混凝土攪拌車通過管理達到費用低、壽命長、效能高的效果，并滿足混凝土運輸要求。對混凝土攪拌車維護保養，在下面幾個方面要達到以下標準：

According to the service conditions of the concrete mixer and the accumulated machine hours of the reference equipment, arrange the maintenance, inspection, maintenance, repair and anti-corrosion of the concrete mixer. Through management, the concrete mixer truck can achieve the effect of low cost, long service life and high efficiency, and meet the requirements of concrete transportation. For the maintenance of concrete mixer truck, the following standards shall be met:

1.供水系統：供水系統水泵及部件齊全完整，無泄漏。

1. Water supply system: the water pump and components of the water supply system are complete without leakage.

2.發動機：運轉無異常，油壓水溫正常，皮帶松緊適宜，濾清器清潔有效。

2. Engine: no abnormal operation, normal oil pressure and water temperature, proper belt tightness, and clean and effective filter.

3.制動系統：手腳制動靈敏有效，不跑偏，壓印、拖印、踏板行程符合規定。

3. Brake system: the hand and foot brake are sensitive and effective, without deviation, and the stamping, dragging and pedal travel meet the requirements.

4.燈光系統：各種儀表齊全，指示數據準確，指示燈齊全、完好，聲光信號及報警系統齊全完整有效。

4. Lighting system: various instruments are complete, indicating data is accurate, indicating lamps are complete and intact, and audible and visual signals and alarm systems are complete, complete and effective.

5.攪拌系統：筒體與托輪接觸良好，不跑偏竄動。攪拌筒葉片無嚴重磨損變形。筒內和出料口無嚴重積料。

5. Mixing system: the cylinder is in good contact with the supporting wheel, without deviation and movement. The blades of mixing drum shall be free from serious wear and deformation. There is no serious material accumulation in the barrel and at the outlet.

6.潤滑系統：和潤滑裝置齊全、完好，油路暢通，潤滑部位潤滑充分，潤滑油型號、油量油質符合規定要求。

6. Lubrication system: and lubricating devices are complete and intact, the oil path is smooth, the lubricating parts are fully lubricated, and the lubricating oil model, quantity and quality meet the specified requirements.

7.電器系統：全車線路完整，連接卡固定符合要求。電瓶整潔，固定牢靠，電解液面符合要求。

7. Electrical system: the whole vehicle line is complete, and the connection card is fixed as required. The battery shall be clean and firmly fixed, and the electrolytic liquid level shall meet the requirements.

8.轉向系統：轉向盤自由轉向量不大于30度，轉向助力裝置靈敏有效，轉向節及臂、轉向橫直拉桿無損傷，球銷不松曠。

8. Steering system: the free steering volume of the steering wheel shall not be greater than 30 degrees, the power steering device shall be sensitive and effective, the steering knuckle, arm and steering straight rod shall not be damaged, and the ball pin shall not be loose.

9.液壓系統：油泵和馬達工作正常，壓力達到額定值。液壓油型號、油量、油質符合規定要求，油溫不大于80℃，油管連接良好，無泄漏現象。

9. Hydraulic system: the oil pump and motor work normally and the pressure reaches the rated value. The model, quantity and quality of hydraulic oil shall meet the specified requirements, the oil temperature shall not exceed 80 ℃, and the oil pipe shall be well connected without leakage.

10.整機要求：全車結構無變形、脫焊、開裂現象，螺栓無松動，各總成、零部件及附屬裝置齊全完整。主要工作性能達到額定指標。全車清潔和無混凝土積料。

10. Complete machine requirements: the whole vehicle structure shall be free of deformation, desoldering and cracking, bolts shall be free of looseness, and all assemblies, parts and accessories shall be complete. The main working performance reaches the rated index. The whole vehicle is clean and free of concrete accumulation.

11.底盤部分：混凝土攪拌車變速箱和分動箱無亂檔現象。前后橋傳動機構無異響和過熱現象。離合器分離，結合平穩，工作可靠。輪胎磨損不超過有關規定，氣壓符合規定，備胎及工具齊全。

11. Chassis: gearbox and transfer case of concrete mixer shall be free of gear disorder. The front and rear axle transmission mechanism shall be free of abnormal noise and overheating. The clutch is separated, and the combination is stable and reliable. The tire wear shall not exceed the relevant regulations, the air pressure shall comply with the regulations, and the spare tire and tools shall be complete.

混凝土攪拌車維護保養達到怎樣的標準？從11個方面來講解了問題，希望對您有所幫助，您平日使用要做好檢查維護工作才行！更多相關信息就來我們網站http://www.jqeq.cn咨詢吧！

What standard does the maintenance of concrete mixer reach? I explained the problem from 11 aspects and hope it will be helpful to you. You should do a good job of inspection and maintenance in daily use! Come to our website for more information http://www.jqeq.cn Consult!